{"status":"ok","message-type":"work","message-version":"1.0.0","message":{"indexed":{"date-parts":[[2026,8,13]],"date-time":"2026-08-13T13:37:35Z","timestamp":1786628255729,"version":"build-2736575974"},"reference-count":37,"publisher":"AIP Publishing","issue":"8","funder":[{"DOI":"10.13039\/501100013388","name":"Office National d\u2019\u00e9tudes et de Recherches A\u00e9rospatiales","doi-asserted-by":"publisher","id":[{"id":"10.13039\/501100013388","id-type":"DOI","asserted-by":"publisher"}]},{"DOI":"10.13039\/501100002830","name":"Centre National d\u2019Etudes Spatiales","doi-asserted-by":"publisher","id":[{"id":"10.13039\/501100002830","id-type":"DOI","asserted-by":"publisher"}]}],"content-domain":{"domain":["pubs.aip.org"],"crossmark-restriction":true},"short-container-title":[],"published-print":{"date-parts":[[2026,8,1]]},"abstract":"<jats:p>The rapid growth of the space industry is driving the development of electric propulsion systems spanning thrust from hundreds of mN down to the \u03bcN range. Conventional plume diagnostic tools are limited by size and versatility, with them being difficult to adapt across testing facilities and thrusters. Moreover, plasma-based sensors, such as Faraday or Langmuir probes, are blind to neutral species, limiting their use for cold gas thruster plumes. To address these limitations, a miniature MEMS-based force probe was developed to directly measure the total momentum flux of impinging particles, enabling total thrust reconstruction. In this work, the calibration and the thrust reconstruction methods for the force probe are developed and validated using a cold gas thruster. Thrust measurements over a range of 200\u2013950 \u03bcN show good agreement with a conventional thrust balance within \u00b15% in the far field and up to \u224830% in the near field. After accounting for the accommodation factor, assuming diffusive particle reflection, the residual discrepancy is attributed to non-uniform pressure distribution across the proof mass and transitional flow regime effects. For the reference case 1 mg s\u22121 of N2, the local pressure measured at 16.5\u00a0cm from the thruster exit plane ranges from 8 to 25 mPa, corresponding to a total thrust of 600 \u03bcN. These results demonstrate that the MEMS force probe is a valid, versatile instrument for thrust measurements and plume diagnostics, providing spatially resolved momentum flux information relevant for the characterization of next-generation electric propulsion systems.<\/jats:p>","DOI":"10.1063\/5.0337416","type":"journal-article","created":{"date-parts":[[2026,8,13]],"date-time":"2026-08-13T13:03:38Z","timestamp":1786626218000},"update-policy":"https:\/\/doi.org\/10.1063\/aip-crossmark-policy-page","source":"Crossref","is-referenced-by-count":0,"title":["A miniature force probe for cold gas thrust measurements"],"prefix":"10.1063","volume":"97","author":[{"ORCID":"https:\/\/orcid.org\/0009-0002-1568-4348","authenticated-orcid":false,"given":"G.","family":"Brandi","sequence":"first","affiliation":[{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 1 , 91120 Palaiseau,","place":["France"]},{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 2 , 92320 Ch\u00e2tillon,","place":["France"]}],"role":[{"vocabulary":"crossref","role":"author"}]},{"ORCID":"https:\/\/orcid.org\/0000-0002-4400-9993","authenticated-orcid":false,"given":"R.","family":"Levy","sequence":"additional","affiliation":[{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 2 , 92320 Ch\u00e2tillon,","place":["France"]}],"role":[{"vocabulary":"crossref","role":"author"}]},{"ORCID":"https:\/\/orcid.org\/0000-0003-0449-0978","authenticated-orcid":false,"given":"S.","family":"Astruc","sequence":"additional","affiliation":[{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 1 , 91120 Palaiseau,","place":["France"]},{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 2 , 92320 Ch\u00e2tillon,","place":["France"]}],"role":[{"vocabulary":"crossref","role":"author"}]},{"ORCID":"https:\/\/orcid.org\/0000-0002-5409-4028","authenticated-orcid":false,"given":"P. Q.","family":"Elias","sequence":"additional","affiliation":[{"name":"DPHY, ONERA, Universit\u00e9 Paris-Saclay 1 , 91120 Palaiseau,","place":["France"]}],"role":[{"vocabulary":"crossref","role":"author"}]}],"member":"317","published-online":{"date-parts":[[2026,8,13]]},"reference":[{"key":"2026081308433991800_c1","volume-title":"Fundamentals of Electric Propulsion: Ion and Hall Thrusters","year":"2008"},{"key":"2026081308433991800_c2","doi-asserted-by":"publisher","first-page":"539","DOI":"10.2514\/1.b35564","article-title":"Recommended practice for thrust measurement in electric propulsion testing","volume":"33","year":"2017","journal-title":"J.\u00a0Propul. Power"},{"key":"2026081308433991800_c3","doi-asserted-by":"publisher","first-page":"105108","DOI":"10.1063\/1.2357315","article-title":"Thrust stand for electric propulsion performance evaluation","volume":"77","year":"2006","journal-title":"Rev. Sci. Instrum."},{"key":"2026081308433991800_c4","doi-asserted-by":"publisher","first-page":"566","DOI":"10.2514\/1.b35531","article-title":"Recommended practice for use of Langmuir probes in electric propulsion testing","volume":"33","year":"2017","journal-title":"J.\u00a0Propul. Power"},{"key":"2026081308433991800_c5","doi-asserted-by":"publisher","first-page":"582","DOI":"10.2514\/1.B35696","article-title":"Recommended practice for use of Faraday probes in electric propulsion testing","volume":"33","year":"2017","journal-title":"J.\u00a0Propul. Power"},{"key":"2026081308433991800_c6","first-page":"17","article-title":"Thrust measurements with the ONERA micronewton balance"},{"key":"2026081308433991800_c7","doi-asserted-by":"publisher","first-page":"043516","DOI":"10.1063\/5.0190318","article-title":"Investigation of the directional Faraday cup and improvement of the comparison between direct and indirect thrust measurements of a magnetic nozzle ECR thruster","volume":"31","year":"2024","journal-title":"Phys. Plasmas"},{"key":"2026081308433991800_c8","doi-asserted-by":"publisher","first-page":"34","DOI":"10.1016\/j.actaastro.2010.07.015","article-title":"A generalization of the rocket formula and its application to advanced space propulsion systems","volume":"68","year":"2011","journal-title":"Acta Astronaut."},{"key":"2026081308433991800_c9","doi-asserted-by":"publisher","first-page":"91","DOI":"10.1140\/epjd\/e2015-50743-2","article-title":"Measurement of the force exerted on the surface of an object immersed in a plasma","volume":"69","year":"2015","journal-title":"Eur. Phys. J. D"},{"key":"2026081308433991800_c10","doi-asserted-by":"publisher","first-page":"105117","DOI":"10.1063\/1.5050553","article-title":"Development of a momentum vector measurement instrument in steady-state plasmas","volume":"8","year":"2018","journal-title":"AIP Adv."},{"key":"2026081308433991800_c11","doi-asserted-by":"publisher","first-page":"085027","DOI":"10.1063\/1.5042011","article-title":"A momentum flux measuring instrument with the variable-range for exhaust plume","volume":"8","year":"2018","journal-title":"AIP Adv."},{"key":"2026081308433991800_c12","doi-asserted-by":"publisher","first-page":"015107","DOI":"10.1063\/1.4905534","article-title":"Instrument for spatially resolved simultaneous measurements of forces and currents in particle beams","volume":"86","year":"2015","journal-title":"Rev. Sci. Instrum."},{"key":"2026081308433991800_c13","doi-asserted-by":"publisher","first-page":"045218","DOI":"10.1063\/5.0066401","article-title":"Thrust measurement of an ion thruster by a force probe approach and comparison to a thrust balance","volume":"12","year":"2022","journal-title":"AIP Adv."},{"key":"2026081308433991800_c14","doi-asserted-by":"publisher","first-page":"115109","DOI":"10.1063\/1.4935471","article-title":"A 10 nN resolution thrust-stand for micro-propulsion devices a 10 nN resolution thrust-stand for micro-propulsion devices","volume":"86","year":"2015","journal-title":"Rev. Sci. Instrum."},{"key":"2026081308433991800_c15","doi-asserted-by":"publisher","first-page":"115002","DOI":"10.1063\/5.0059081","article-title":"Design, fabrication, and calibration of a micro-load cell for micro-resistojet development","volume":"92","year":"2021","journal-title":"Rev. Sci. Instrum."},{"key":"2026081308433991800_c16","article-title":"Advances in force probe techniques"},{"key":"2026081308433991800_c17","article-title":"A novel method for simultaneous measurements of indirect thrust, ion beam distribution and thrust vector motion of electric propulsion systems"},{"key":"2026081308433991800_c18","first-page":"1","article-title":"Digital electronics for inertial MEMS and space applications","year":"2018"},{"key":"2026081308433991800_c19","article-title":"Thrust measurements using plasma pressure measurements in the plume: A feasibility"},{"key":"2026081308433991800_c20","article-title":"Thrust measurement using a plasma pressure probe immersed in the plume"},{"key":"2026081308433991800_c21","first-page":"1","article-title":"Compensation of perturbative effects on a thrust measurement MEMS probe for electric propulsion","year":"2021"},{"key":"2026081308433991800_c22","unstructured":"S.\n            Astruc\n          , \u201cConception et validation d\u2019un micro-capteur pour la mesure de pouss\u00e9e de propulseurs \u00e9lectriques de satellites,\u201d Ph.D. thesis, Universit\u00e9 Paris-Saclay-\u00c9cole doctorale Ondes et mati\u00e8re, 2023."},{"key":"2026081308433991800_c23","unstructured":"B. L.\n            Foulgoc\n          , \u201c\u00c9valuation du potentiel de performances micro-acc\u00e9l\u00e9rom\u00e8tres inertiels vibrants en silicium,\u201d Ph.D. thesis, Universit\u00e9 Paris-Est, 2008."},{"key":"2026081308433991800_c24","article-title":"Concepts and limits for the miniaturization of silicon differential vibrating inertial micro-beam accelerometer"},{"key":"2026081308433991800_c25","doi-asserted-by":"publisher","first-page":"1323","DOI":"10.2514\/1.b37036","article-title":"Direct thrust measurement of an electron cyclotron resonance plasma thruster","volume":"34","year":"2018","journal-title":"J.\u00a0Propul. Power"},{"key":"2026081308433991800_c26","doi-asserted-by":"publisher","first-page":"33","DOI":"10.1007\/s44205-022-00034-7","article-title":"Experimental characterization of thrust production mechanisms in a magnetic nozzle ECR thruster","volume":"1","year":"2022","journal-title":"J.\u00a0Electr. Propul."},{"key":"2026081308433991800_c27","unstructured":"R.\n            Pioch\n          , \u201cIon dynamics in the magnetic nozzle of an electron cyclotron resonance thruster,\u201d Ph.D. thesis, Institut Polytechnique de Paris (EDIPP), 2024."},{"key":"2026081308433991800_c28","doi-asserted-by":"publisher","first-page":"934","DOI":"10.2514\/1.b35091","article-title":"Thrust measurements of the gaia mission flight-model cold gas thrusters","volume":"30","year":"2014","journal-title":"J.\u00a0Propul. Power"},{"key":"2026081308433991800_c29","article-title":"Numerical study of the interaction between a plasma beam and a thrust probe"},{"key":"2026081308433991800_c30","doi-asserted-by":"publisher","first-page":"929","DOI":"10.1016\/0032-0633(65)90150-9","article-title":"Satellite drag coefficients","volume":"13","year":"1965","journal-title":"Planet. Space Sci."},{"key":"2026081308433991800_c31","volume-title":"Measurement and Analysis of a Small Nozzle Plume in Vacuum","year":"1992"},{"key":"2026081308433991800_c32","doi-asserted-by":"publisher","first-page":"56","DOI":"10.1016\/j.paerosci.2013.09.001","article-title":"Spacecraft drag modelling","volume":"64","year":"2014","journal-title":"Prog. Aerosp. Sci."},{"key":"2026081308433991800_c33","article-title":"Rarefied transitional bridging of blunt body aerodynamics,"},{"key":"2026081308433991800_c34","year":"1991","journal-title":"Modelling of aerodynamic forces and heat transfer for orbital decay and reentry calculations"},{"key":"2026081308433991800_c35","doi-asserted-by":"publisher","first-page":"1405","DOI":"10.1016\/0032-0633(91)90020-b","article-title":"Application of a satellite aerodynamics model based on normal and tangential momentum accommodation coefficients","volume":"39","year":"1991","journal-title":"Planet. Space Sci."},{"key":"2026081308433991800_c36","volume-title":"Molecular Gas Dynamics and the Direct Simulation of Gas Flows","year":"1994"},{"key":"2026081308433991800_c37","doi-asserted-by":"publisher","first-page":"16","DOI":"10.2514\/3.26992","article-title":"High-altitude capsule aerodynamics with real gas effects","volume":"35","year":"1998","journal-title":"J.\u00a0Spacecr. Rockets"}],"container-title":["Review of Scientific Instruments"],"original-title":[],"language":"en","link":[{"URL":"https:\/\/pubs.aip.org\/aip\/rsi\/article-pdf\/doi\/10.1063\/5.0337416\/21105299\/085001_1_5.0337416.pdf","content-type":"application\/pdf","content-version":"vor","intended-application":"syndication"},{"URL":"https:\/\/pubs.aip.org\/aip\/rsi\/article-pdf\/doi\/10.1063\/5.0337416\/21105299\/085001_1_5.0337416.pdf","content-type":"unspecified","content-version":"vor","intended-application":"similarity-checking"}],"deposited":{"date-parts":[[2026,8,13]],"date-time":"2026-08-13T13:03:42Z","timestamp":1786626222000},"score":1,"resource":{"primary":{"URL":"https:\/\/pubs.aip.org\/rsi\/article\/97\/8\/085001\/3400970\/A-miniature-force-probe-for-cold-gas-thrust"}},"subtitle":[],"short-title":[],"issued":{"date-parts":[[2026,8,1]]},"references-count":37,"journal-issue":{"issue":"8","published-print":{"date-parts":[[2026,8,1]]}},"URL":"https:\/\/doi.org\/10.1063\/5.0337416","relation":{},"ISSN":["0034-6748","1089-7623"],"issn-type":[{"value":"0034-6748","type":"print"},{"value":"1089-7623","type":"electronic"}],"subject":[],"published-other":{"date-parts":[[2026,8]]},"published":{"date-parts":[[2026,8,1]]},"article-number":"085001"}}